Rule changes

One major rule change regarding time trials was implemented for 1982. All cars would be allowed only two warm up laps for qualifying, down from three, which had been the rule since 1946.^[7]

After two major pit fires in 1981 (Rick Mears at the Indianapolis 500 and Herm Johnson at the Michigan 500), new safety rules were implemented. Pit side fuel tanks were required to be anchored to the ground, while new high-pressure water hoses were installed the length of the pit lane. Significant improvements were also made to the fuel couplings, fuel hoses, vent hoses, and "buckeyes" on the cars themselves. Positive shutoff valves on the pitside fuel tanks were also made mandatory. All pit personnel were required to wear fire-resistant clothing, including not only the over-the-wall crew, but others including scorers, etc.^[8] Likewise, it would become the norm that even pit reporters for television and radio began wearing specialized firesuits as well.

During the month of May 1981, word had been buzzing around the garage area that USAC was preparing to drastically change the engine formula for 1982 and beyond. The ruling would effectively ban the popular Cosworth DFX V-8, the engine that had won the Indianapolis 500 the previous four years (1978-1981). The plan was to craft the rules to require (or heavily favor) production-based, "stock block" engines, and reduce turbocharger boost to noncompetitive levels (to discourage their use), or ban turbochargers outright.^[9] However, during the summer of 1981 the decision was changed. The turbocharged OHC V-8 engines (namely the Cosworth DFX) would continue to be permitted, only with a smaller turbocharger unit.^[10] Teams applauded the decision, and the 1982 race would be contested with mostly similar engine specifications as the previous year.^[11]

Pole day—death of Gordon Smiley

On pole day, Saturday, May 15, Kevin Cogan, driving for Penske Racing set a new one-lap track record of 204.638 mph (329.333 km/h), and a record four-lap average of 204.082 mph (328.438 km/h). A few minutes later, he was beaten by his Penske teammate Rick Mears. Mears secured the pole position with a four-lap average of 207.004 mph (333.141 km/h). A total of nine cars completed runs, including Gordon Johncock, rookie Bobby Rahal, and Danny Ongais.

At 12:15 p.m., the time trials were marred by the horrifying fatal accident of Gordon Smiley. Smiley left the pits to start his qualifying run. On his second (of two) warm up laps, he approached turn three. The back-end of the #35 Intermedics March 81C-Cosworth became loose, and Smiley over-corrected. The front wheels suddenly gained traction, the car turned and crashed head-on into the concrete wall at about 200 mph (320 km/h). The impact of the March chassis against the wall was so hard and so violent, that the fuel tank exploded with a large fireflash, the car broke into three large sections, and the rest disintegrated into hundreds of pieces. Most of the shattered car went airborne for at least 50 feet (15 m), littering the track with debris. Smiley's exposed body tumbled with the wreck hundreds of feet through the short-chute connecting turns three and four. Pieces of the car were strewn all over the track. Smiley was killed instantly from the massive trauma inflicted by the impact. According to CART medical official Steve Olvey, who was working the event, the impact was so violent that nearly every bone in Smiley's body had been shattered. Olvey also noticed an unusual gray substance on the track, which marked a trail leading to the driver. The substance was later discovered to be most of Smiley's brain.^[12] His helmet was pulled from his head during the impact.

Smiley's death was the first at Indy since 1973, and to date, the last during a qualification attempt.^[13] Since it occurred in the remote area of turn three, and without video boards or live television, a vast majority of the fans in attendance did not see the crash up close or the immediate aftermath.

Olvey published his autobiography Rapid Response: My Inside Story as a Motor Racing Life-Saver in 2006, where noted numerous drivers advised Smiley that his road racing approach to driving around the Speedway was unsuitable for ovals in a ground-effects car. Smiley had competed in the SCCA National Championship Runoffs, winning two championships and then the Aurora AFX1 Championship, where he won at Silverstone Circuit, the latter of which were in older Formula One cars. ^[14]

About 33 minutes after the wreck; at precisely 12:48 PM, track announcer Tom Carnegie learned of Smiley's fate for the first time. He immediately informed the fans watching from the grandstands: "Ladies and gentlemen... it is with our deepest regrets that we announce the passing of Gordon Smiley."

The track remained closed for over two hours after the crash. The catch fencing needed repair, debris littered the track, and a patch of asphalt was required to repair a gash in the racing surface. After over two hours, a couple cars were dispatched by the officials to test the pavement, and they deemed it suitable for qualifying to resume. Several cars went out over the next two hours, but none challenged the speed records set earlier in the morning. A. J. Foyt put his car on the outside of the front row, and Mario Andretti qualified fourth. In a solemn mood, qualifying came to a halt around 4:55 p.m., with just over an hour left in the session.

At the close of pole day, the field was filled to 20 cars.

Second day

After the tragic circumstances of the previous day, few drivers took to the track on Sunday, May 16. A very uneventful day saw only a handful of cars even take practice laps. Only a few cars made qualifying attempts and only two were run to completion. Rain ended the session a few minutes early, and the field was filled to 22 cars.

Third day

The second week of practice saw increased track activity. The third day of time trials was scheduled for Saturday, May 22. A busy day of qualifying saw the field filled to 31 cars. Mike Chandler was fastest of the day at 198.042 mph (318.718 km/h).

Bump day

On Sunday, May 23, the field was left with two empty positions at the start of the day. Several drivers intended to make attempts but few actually took to the track. Josele Garza and Pete Halsmer went out and quickly filled the field. Only two cars were bumped all day, and despite the track being open until 6 p.m., no drivers went out after 4:03 p.m. With two hours left in the day, Desiré Wilson announced she would not make an attempt, and thus would not have a chance to become the second female to qualify at Indy.

Aftermath

Cogan quickly fell out of favor following the humiliation stemming from the accident. It was followed by a noticeable "blacklisting" by fans and press.^[19] Cogan nearly had the dubious distinction of taking out two of the most famous American auto racing legends and the two most successful IndyCar drivers of all time (Foyt and Andretti) on the first lap, in one move, in the biggest race of the season. The incident also further rehashed a standing feud between Penske Racing and Patrick Racing. A year earlier, Penske and Patrick had been the key fixtures in the controversial 1981 race.

Cogan did not manage to win a race in 1982, and was possibly fired by Roger Penske because of it and replaced by Al Unser in 1983.^[20]

The accident was never explained by the Penske team. Derrick Walker the team manager at the time, claimed that they found "no cause" for the accident.^[21] However, several experts had differing opinions. Rodger Ward, working for the IMS Radio Network immediately believed the rear brakes locked up.^[17] It was a common practice for drivers in the turbocharged era to "ride the brakes" during warm up laps in order to engage the turbocharger. Others theorized it may have happened due to a broken CV joint or halfshaft. Fellow drivers such as Johnny Rutherford and Gordon Johncock suggested that due to the slow start, Cogan may have been in first gear, and when he accelerated, the back end simply came around.^[17] Some feel that Sam Posey on ABC-TV inadvertently may have added to the controversy when he proclaimed "absolutely no idea" to the question of how it could have happened,^[15] and saying "it was as if he turned the wheel intentionally."^[15] The comments led many to conclude that the accident may have been entirely of Cogan's doing. As soon as he climbed from the car, Cogan was observed looking at the rear end axle, suggesting that he thought something broke, which Cogan believes was the problem.

One year later, in an autobiography detailing his career up to that point, Foyt gave a somewhat more analytical account of what occurred than he had before, while still assigning Cogan nearly all of the responsibility. According to Foyt, the slow straightaway pace previously noted by Unser and Rutherford had been beneath the power-amplification threshold of the turbocharger, which provides a progressively higher energy boost to the engine the higher the engine's RPM. Due to the pace, competitors had to run in lower gears much later than they normally did when approaching the start. Foyt in turn maintained that Cogan had intended to jump both Foyt and Mears into the first turn through the 'stupid trick' of using lower gears, via the significantly faster acceleration they provided compared to higher gears. When Mears' insufficient pace precluded this strategy, Foyt accused Cogan of simply 'jump[ing] on it' early, even before the green flag had fully come out, whereby the resulting explosive power increase caused the car to veer sideways and '[get] away from him'. Any broken half shaft, Foyt finally stated, was merely due to the subsequently unavoidable collision with Andretti.^[22]

Years later Donald Davidson, the historian for the Indianapolis Motor Speedway, mentioned that team driver, and the more experienced, Rick Mears had a nearly identical accident during private testing at Michigan.^[23][24][25] In 2009, Roger Penske seemed to brush off ideas, stating "Cogan said something broke, I don't know whether it did or didn't."^[26]

Alternates

• Chip Mead  R  (#49) - First alternate
• Bill Alsup (#2) - Second alternate

Failed to Qualify

First half

According to the rules, the cars are required to maintain a minimum fuel economy of 1.8 miles per gallon. To complete two parade laps, one pace lap, and the 200 laps for the race, each car is allotted 280 US gallons (1,100 L) of methanol fuel in their pitside tank. Due to the aborted start, officials took the time to replenish approximately 5.6 US gallons (21 L) of fuel to each team's pitside tank.

Overall, the delay stemming from the Cogan accident lasted over 45 minutes. Only 29 cars lined up for the second start attempt.

A. J. Foyt took the lead at the start. It was the first time in his 25-year Indy career that he led the first lap of the race. After the hasty repairs from the Cogan incident, Foyt's car was precariously unproven, yet Foyt made no effort to "feel his car out" before charging into the lead. Meanwhile, popular second-year driver Josele Garza barely completed the first lap, and dropped out with an oil leak.

Rick Mears soon established himself as the fastest car in the field, and found the lead in the first half.

A. J. Foyt's day ended just short of the midway point. A failed transmission linkage prevented him from pulling out of the pits. Foyt famously climbed from the cockpit, grabbed a hammer and a screwdriver, and started pounding away at the rear mechanics of the car. His attempts were futile, and the car was wheeled back to the garage area. Foyt revealed, during an interview immediately thereafter, that the Cogan crash had damaged the car's toe in alignment, and that it had been handling poorly all race up to that point. The 1982 race would be the final Indy 500 Foyt would lead during his driving career.

Finish

Gordon Johncock leads Rick Mears in the closing stages of the race.

On a restart with 40 laps to go, Gordon Johncock came up to speed faster and passed Rick Mears for the lead on the backstretch. Most of the balance of the field was eliminated, or running several laps behind. Johncock was unable to pull away and the two cars ran nose to tail for the next twenty laps, with Mears handling better in the turns but Johncock able to find enough speed at the end of the straightaway to keep Mears from passing. Both drivers needed to make one final pit stop for fuel in order to make it to the finish.

With 18 laps to go Mears ducked into the pits. Racing down the pit lane, he found himself suddenly trapped behind the slower car of Herm Johnson. Mears locked up the brakes and bumped into Johnson's back wheel. The incident cost Mears several seconds. In his pit box, the Penske crew proceeded to fill his car full with 40 US gallons (150 L) of fuel, more than enough needed to make it to the finish. No tires were changed, and the crew determined that no damage was sustained from hitting Johnson's car.

Two laps later, Johncock dove into the pits. He precariously diced around the slower car of Jim Hickman and slid into his pit box. The Patrick Racing crew conducted a timed pit stop. The team calculated the amount of fuel needed to make it to the finish. When enough fuel had flowed into the car, a pit crew member tapped the fuel man on his back with a stick, and he disengaged. Johncock pulled away, with a pit stop many seconds quicker than that of Mears.

Back on the track, Johncock held a lead of more than eleven seconds. It seemed he was cruising to his second Indy victory. However, his car's handling was starting to suffer. The light fuel load he took on was exacerbating a pushing condition.

Meanwhile, Mears' fully fueled car was heavier, and handling much better. He started closing in, more than one second per lap. Johncock started driving very low in the turns, trying to alleviate the pushing condition. It became clear in the waning laps that Mears was dramatically closing in on the lead. Such a circumstance was nearly unprecedented in Indy 500 history, occurring only once before in the 1937 race. With only six other cars left running, traffic was not a factor.

Mears closed to under 3 seconds with three laps to go. With two laps to go, the margin was less than 1 second. With one lap to go, Mears pulled alongside on the mainstretch. The cars took the white flag side by side but Johncock refused to give up the lead. Once again pulling slightly ahead at the end of the straightaway, he "chop-blocked" Mears in the first turn and stayed ahead. Mears lost momentum but began to reel Johncock back in down the backstretch. In turn three, Johncock drove so low that he hit a bump on the inside of the track and nearly lost control. As they exited turn four, Mears tried to slingshot pass Johncock for the win. Johncock held off the challenge and won by 0.16 seconds, the closest finish in Indy 500 history at the time. Mears lost by just over one car length. It would stand as the closest finish in race history for ten years.

In Victory Lane, Johncock admitted to having been worried about his car's deteriorating handling as he watched Mears get closer and closer in his mirrors. He said that he had had no intention of backing off in turn one on the last lap and was prepared to go through the corner side by side if necessary. Mears, when interviewed by Bill Flemming after the race, seemed less disappointed about finishing second than thrilled to have been a part of the most dramatic finish in Indy history. Mears had noticed that Johncock's handling was going away, quipping that Johncock "had 'er everywhere but straight", and praised him for the ability to overcome such a challenge. Mears also conceded that Johncock's block in turn one was not a dirty move and admitted that "it was [Johncock's] corner." In interviews in later years Mears said that he would not change the result of the race even if he could, although he jokingly claimed to have watched the tape over and over again "to see if this time I get by Gordy."

Radio

The race was carried live on the IMS Radio Network. Paul Page served as anchor for the sixth year. Lou Palmer reported from victory lane. The broadcast came on air at 10:15 a.m. local time, providing a 45-minute pre-race for the final time. The following year the pre-race coverage was expanded to a full hour.^[35] Several assignments were shifted, and a new member was added, Sally Larvick, who served as a roving reporter, interviewing celebrities and other dignitaries. Larvick, wife of Paul Page, was believed to be the second female reporter in the history of the network. At the start of the race, roving reporter Bob Forbes rode in one of the pace cars on the parade lap. Veteran Howdy Bell moved to the backstretch, Doug Zink moved from turn three to turn two, and Larry Henry took over the third turn position.

For 1982, the famous commercial out cue of the network was changed to "Now stay tuned for the Greatest Spectacle in Sports!"

The broadcast crew was critically acclaimed for their collective call of the closing laps of the 1982 race.

Television

The race was carried in the United States on ABC Sports on a same-day tape delay basis. After controversy the previous year, Jackie Stewart was moved from the booth to a new host position in "ABC Race Central." Sam Posey returned to the booth as driver expert, and Jack Whitaker joined the crew for in-depth features and commentary. Whitaker rode along and reported live from inside the pace car at the start of the race. Clyde Lee, anchorman for WRTV (ABC's affiliate in Indianapolis), was also on hand to report on drivers who happened to drop out of the race, as well as from the infield hospital.

Producer Mike Pearl would receive a Sports Emmy award for his efforts in the telecast, which won three total.

Pole day time trials on ABC featured Al Michaels, Jackie Stewart, and Sam Posey.

The broadcast has re-aired numerous times on ESPN Classic since April 2000. In May 2004, the broadcast was featured on ESPN Classic's "Big Ticket" series, featuring interviews with Gordon Johncock and Rick Mears, hosted by Gary Miller.